炎炎夏日，搅拌车很容易发生自燃现象。即便是在寒冷的冬季，自燃也很常见，火势的速度和紧迫性无济于事，所以说一定要注意这些隐患！

In hot summer, the mixer truck is prone to spontaneous combustion. Even in cold winter, spontaneous combustion is very common, and the speed and urgency of the fire do not help, so we must pay attention to these hidden dangers!

短路导致发动机自燃

Short circuit leads to spontaneous combustion of engine

长期行驶后，小型搅拌车车内各部件不可避免地会老化损坏。然而，在日常保养中，驾驶员通常更关注车辆表面的可见问题。然而，电路隐藏在搅拌车内部，因此驾驶员不能总是注意其工作状态。

After long-term driving, the components in the small mixer truck will inevitably be aged and damaged. However, in daily maintenance, drivers usually pay more attention to the visible problems on the vehicle surface. However, the circuit is hidden inside the mixer truck, so the driver cannot always pay attention to its working state.

一旦车内线路老化，绝缘橡胶断裂，搅拌车的散热功能就会失效，导致自燃。此外，由于司机自己对搅拌车改装不当，可能造成搅拌车电路过载、短路，还可能发生自燃。

Once the lines in the vehicle are aged and the insulating rubber is broken, the heat dissipation function of the mixer will fail, resulting in spontaneous combustion. In addition, due to the improper modification of the mixer truck by the driver himself, the circuit of the mixer truck may be overloaded, short circuited, and spontaneous combustion may occur.

发动机高温点火燃油长期使用后，不仅电路，但搅拌车的油路也可能出现各种问题。油箱老化漏油。夏天的温度已经很高了。在不断的作用下，发动机的温度会更高。如果温度达到油的燃点，可能会引燃燃油并引起自燃。

After long-term use of engine high-temperature ignition fuel, various problems may occur not only in the circuit, but also in the oil circuit of the mixer truck. The oil tank is aging and leaking oil. The temperature in summer is already very high. Under constant action, the temperature of the engine will be higher. If the temperature reaches the ignition point of the oil, it may ignite the fuel and cause spontaneous combustion.

车辆自燃往往与油路、线路故障有关，作业单位应做好检查和隐患排查，避免事故发生。

Vehicle spontaneous combustion is often related to oil circuit and line faults. The operation unit should do a good job in safety inspection and hidden danger troubleshooting to avoid accidents.

刹车引起的自燃

Spontaneous combustion caused by braking

车轮火灾是汽车自燃的主要因素之一。满载和长时间运行使车轮温度过高，导致自燃。轮胎自燃温度一般在130度左右，车辆在运输过程中应定期停车休息，以减轻车轮负荷。轮胎与路面和相邻轮胎之间的摩擦也容易导致车辆自燃。超载和超限是爆胎的重要原因之一。从目前的交通环境来看，超限超载是常见的行为。

Wheel fire is one of the main factors of auto spontaneous combustion. Full load and long-term operation make the wheel temperature too high, leading to spontaneous combustion. The tire spontaneous combustion temperature is generally about 130 degrees. The vehicle should stop regularly during transportation to reduce the wheel load. The friction between the tire and the road and the adjacent tire is also easy to cause spontaneous combustion of the vehicle. Overloading and overrun are one of the important reasons for tire blowout. From the current traffic environment, overload is a common behavior.

定期更换灭火器，以降低自燃风险。

Replace fire extinguishers regularly to reduce the risk of spontaneous combustion.

目前大多数搅拌车出厂时都配备了灭火器，有效期一般为一两年。同时定期检查。当压力表低于绿线区域时，应及时充注和维护。

At present, most mixer trucks are equipped with fire extinguishers when leaving the factory, which are generally valid for one to two years. At the same time, check regularly. When the pressure gauge is lower than the green line area, it should be filled and maintained in time.

大多数车辆自燃是由于车辆使用不当引起的。只要多检查车辆状况，就能降低车辆自燃的概率。更多相关内容您可以来关注我们网站http://www.zkzsljbc.com咨询看看！

Most vehicle spontaneous combustion is caused by improper use of vehicles. As long as the vehicle condition is checked more, the probability of vehicle spontaneous combustion can be reduced. You can follow our website for more relevant content http://www.zkzsljbc.com Consult!