自上料搅拌车的使用与保养是息息相关的，要懂得巧妙地使用自上料搅拌车才能省去很多不必要的麻烦。接下来一起来看看驾驶时的注意事宜，了解的知识越深，对于自上料搅拌车的使用保养就会越轻松。

The use and maintenance of the self loading mixer are closely related. You should know how to use the self loading mixer skillfully to save a lot of unnecessary trouble. Next, let's take a look at the precautions when driving. The deeper you know, the easier it will be to use and maintain the self feeding mixer.

1、自上料搅拌车作业设备连续工作时刻不该超越8h。运送混凝土的容量，质量及塌落度应契合混凝土行业标准和要求。

1. The continuous working time of the operation equipment from the charging mixer shall not exceed 8h. The capacity, quality and slump of delivered concrete shall conform to the standards and requirements of the concrete industry.

2、自上料搅拌车水箱的水量要经常加满，以备急用。水箱加水前，有必要翻开放气阀把箱内空气放掉；冲刷时翻开气阀，冲刷完毕或许停用时应将水罐内气体放掉。冬天停放时，水箱和供水体系里，不得有剩下水，避免冻裂。注意：水箱仅在供水时加压,不要带着加压水箱在公路上行进。

2. The water tank of the self feeding mixer shall be filled frequently for emergency use. Before the water tank is filled with water, it is necessary to turn over the air valve to drain the air in the tank; Open the air valve when flushing, and discharge the air in the water tank after flushing or when it is out of service. When parking in winter, there shall be no water left in the water tank and water supply system to avoid frost cracking. Note: The water tank is pressurized only when supplying water. Do not carry the pressurized water tank on the road.

3、自上料搅拌车在混凝土运送过程中罐体制止停转，避免形成混凝土的凝聚，停转重启时会形成对液压体系、减速机的冲击，致使液压泵和马达的损坏。

3. Stop the stop of the tank of the self feeding mixer during the concrete delivery process to avoid the formation of concrete condensation. The stop and restart will cause impact on the hydraulic system and reducer, causing damage to the hydraulic pump and motor.

4、满载混凝土正转，如要回转，有必要操作手柄使正转停稳后，再操作手柄回转。禁止正转过程中操作手柄使其回转。

4. Full load concrete rotates forward. If it is necessary to rotate, it is necessary to operate the handle to make the forward rotation stop stably, and then operate the handle to rotate. Do not operate the handle to rotate it during forward rotation.

5、自上料搅拌车卸料时，如发现水分蒸腾，塌落度偏低不能满意用户要求时，可适当向筒内加水，然后以10—14r/min的速度旋转30转后卸料，使混凝土充分拌和。

5. When discharging from the charging mixer truck, if it is found that the water transpiration and slump are too low to meet the user's requirements, water can be properly added into the cylinder, and then the concrete can be fully mixed after 30 revolutions at the speed of 10-14r/min.

6、拌和车在空载运转过程中，拌和筒不得停转避免波动时形成滚道和托轮部分磕碰，致使托轮和滚道的反常损坏。

6. During the no-load operation of the mixing truck, the mixing drum shall not stop to avoid the roller path and roller path from colliding with each other in case of fluctuation, which may cause abnormal damage to the roller and roller path.

自上料搅拌车在公路上行驶时，加长溜槽有必要放置在卸料溜槽支架上并用挂钩挂牢，不允许挂在主排料溜槽上运转；主排料溜槽要旋转到固定方位，拉下定位手柄，用锁紧手柄将绷簧变幅机构锁止，避免由于不固定而摇摆，形成伤人事端和影响其它车辆运转能。更多相关内容就来我们网站http://www.zkzsljbc.com进行咨询吧！

When the self loading mixer is driving on the road, it is necessary to place the extended chute on the discharge chute bracket and hang it firmly with hooks. It is not allowed to hang it on the main discharge chute for operation; The main discharge chute shall be rotated to a fixed position, the positioning handle shall be pulled down, and the tension spring luffing mechanism shall be locked with the locking handle to avoid swinging due to non fixation, which may cause personal injury and affect the operation of other vehicles. More relevant content will come to our website http://www.zkzsljbc.com Consult!