全自动搅拌车搅拌器的动力由二级底盘的动力提取器通过传动轴传递给液压泵。液压泵产生的液压能量通过油管传递给液压马达。液压马达将液压能量转化为动能，通过减速机输送到搅拌槽。使用一段时间后，过多过少的搅拌桶就会出现搅拌不转的情况，一般有三种情况:

The power of the mixer of the fully automatic mixer is transmitted to the hydraulic pump through the drive shaft by the power extractor of the secondary chassis. The hydraulic energy generated by the hydraulic pump is transmitted to the hydraulic motor through the oil pipe. The hydraulic motor converts hydraulic energy into kinetic energy and transmits it to the mixing tank through the reducer. After being used for a period of time, too many or too few mixing drums will cause mixing not to turn. Generally, there are three situations:

混凝土在运输过程中被卡住;

The concrete is stuck during transportation;

液压系统或发动机故障;

Hydraulic system or engine failure;

马达出故障了。

The motor is out of order.

1.混凝土在运输过程中被卡住话，清理干净就没有问题了。

1. If the concrete is stuck during transportation, it will be no problem to clean it up.

2.液压系统或发动机故障处理:

2. Troubleshooting of hydraulic system or engine:

(1)打开搅拌桶人孔盖，松开马达上高压软管的管接头，旋转搅拌桶使搅拌桶人孔斜向下，从搅拌桶人孔排出混凝土;

(1) Open the manhole cover of the mixing drum, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing drum to make the manhole of the mixing drum incline downward, and discharge the concrete from the manhole of the mixing drum;

(2)麻烦卡车高压软管从救济的电动机用高压软管连接到另一端的油泵救援车,后将用于紧急回水管有麻烦卡车机油口、回油管另一端用泵抽油口后救援车辆,使用救援车来控制麻烦卡车的旋转圆柱,具体的排放。

(2) The high pressure hose of the trouble truck is connected from the relief motor to the oil pump rescue vehicle at the other end with the high pressure hose, and then will be used for the emergency water return pipe with the trouble truck oil port, and the other end of the oil return pipe will be used for the rescue vehicle after the pump oil port, and the rescue vehicle will be used to control the rotating cylinder of the trouble truck, and the specific discharge.

3、电机故障，处理相对简单，可将电机从救援车上拆下安装在故障车上，然后将各油管连接起来，启动救援车时可将混凝土气缸混出。

3. The treatment of motor fault is relatively simple. The motor can be removed from the rescue vehicle and installed on the fault vehicle, and then the oil pipes can be connected. When starting the rescue vehicle, the concrete cylinder can be mixed out.

全自动搅拌车应遵守交通部养护维修规定，实行“定期检查、强制养护、视情维修”的养护制度。在这个大前提下，结合全自动搅拌车实际情况，做好养护维修工作。在日常养护方面，车辆应按照汽车发动机、底盘等部件的日常养护，还必须做好相关的养护工作。更多相关内容就来我们网站http://www.zkzsljbc.com咨询吧！

The fully automatic mixing truck shall comply with the maintenance regulations of the Ministry of Communications and implement the maintenance system of "regular inspection, compulsory maintenance, and maintenance as appropriate". Under this premise, the maintenance work shall be done well in combination with the actual situation of the fully automatic mixer. In terms of daily maintenance, the vehicle shall be maintained according to the daily maintenance of the engine, chassis and other parts of the vehicle, and the relevant maintenance work must be done well. Come to our website for more relevant content http://www.zkzsljbc.com Ask!